Development of A multichannel data acouisition and analysis software for the experimental investigation of cavitating flows in pumps
Pompalardaki kovitasyonlu akışların deneysel incelenmesi için çok kanallı veri alma ve analizi yazılımın geliştirilmesi
- Tez No: 35778
- Danışmanlar: PROF. DR. O. CAHİT ERALP
- Tez Türü: Yüksek Lisans
- Konular: Makine Mühendisliği, Mechanical Engineering
- Anahtar Kelimeler: Kavitasyon, Pompalar, Veri analizi, Cavitation, Centrifugal Pumps, Pressure Transducers, A/D Converter Card, Spectral Analysis, Pumps, Data analysis
- Yıl: 1994
- Dil: İngilizce
- Üniversite: Orta Doğu Teknik Üniversitesi
- Enstitü: Fen Bilimleri Enstitüsü
- Ana Bilim Dalı: Makine Mühendisliği Ana Bilim Dalı
- Bilim Dalı: Belirtilmemiş.
- Sayfa Sayısı: Belirtilmemiş.
Özet
oz POMPALARDAKİ KAVİTASYONLU AKIŞLARIN DENEYSEL İNCELENMESİ İÇİN ÇOK KANALLI VERİ ALMA VE ANALİZİ YAZILIMIN GELİŞTİRİLMESİ BİLGEN, İsmail Hakkı Yüksek Lisans Tezi, Makina Mühendisliği Ana Bilim Dalı Tez Yöneticisi: Prof. Dr. O. Cahit ERALP Haziran, 1994, 220 sayfa Santrifüj pompalardaki kavitasyon sorununu incelemek için değişik debi ve emme basınçlarında deneysel bir araştırma yapılmıştır. Deneyler sabit debide emme basıncının, dolayısıyla net pozitif emme yüksekliğinin düşürülmesinin etkisi ve bunun farklı debilerde tekrar edilmesi üzerine planlanmıştır. Pompa girişinde farklı noktalara yerleştirilen iki basınç duyargası ile akıştaki basınç değişiklikleri analog veri olarak kaydedilmiştir. Alınan analog verilerin sayısal verilere dönüştürülmesi, 100 kHz kapasiteli PCL-818 Advantech A/D çevrim kartı ve bu kartın programlanması ile gerçekleştirilmiştir. Basınç sinyallerinin analogdan sayısala çevrimi ve izgesel analizi için bir yazılım paketi geliştirilmiştir. Bu yazılımın doğru çalıştığı yapılan denemelerle kanıtlanmıştır. Kavitasyonun başlangıç ve gelişimini incelemek için verilerin güç izgesi araştırılmıştır. Ortaya çıkan sonuçlan desteklemek için iki farklı aralıktaki frekans değerlerinin RMS oranlarını karşılaştırarak, enerji içeriği çözümlemesiABSTRACT DEVELOPMENT OF A MULTICHANNEL DATA ACQUISITION AND ANALYSIS SOFTWARE FOR THE EXPERIMENTAL INVESTIGATION OF CAVITATING FLOWS IN PUMPS BİLGEN, Ismail Hakkı M.S. in Mechanical Engineering Supervisor: Prof. Dr. O. Cahit ERALP June 1994, 220 pages An experimental research for investigating the cavitation problem of centrifugal pumps at different flowrate and suction pressure is performed. Experiments were planned on the effect of decreasing the suction pressure, consequently the net positive suction head, at constant flowrate and repeating this at different flowrates. The pressure changes are recorded as analog data through the pressure transducers located at different places of the pump inlet. The conversion of the acquired analog data into digital data is performed by programming a PCL-818 Advantech A/D converter card of 100 kHz capacity. A software package was developed for the analog to digital conversion and spectral analysis of the pressure signals. It was proved that the developed software run properly after performing several case studies. The power spectra of the data were investigated in order to detect the inception and extent of cavitation. Energy content analysis was also used to support the revealed results by comparing the m
Özet (Çeviri)
ABSTRACT DEVELOPMENT OF A MULTICHANNEL DATA ACQUISITION AND ANALYSIS SOFTWARE FOR THE EXPERIMENTAL INVESTIGATION OF CAVITATING FLOWS IN PUMPS BİLGEN, Ismail Hakkı M.S. in Mechanical Engineering Supervisor: Prof. Dr. O. Cahit ERALP June 1994, 220 pages An experimental research for investigating the cavitation problem of centrifugal pumps at different flowrate and suction pressure is performed. Experiments were planned on the effect of decreasing the suction pressure, consequently the net positive suction head, at constant flowrate and repeating this at different flowrates. The pressure changes are recorded as analog data through the pressure transducers located at different places of the pump inlet. The conversion of the acquired analog data into digital data is performed by programming a PCL-818 Advantech A/D converter card of 100 kHz capacity. A software package was developed for the analog to digital conversion and spectral analysis of the pressure signals. It was proved that the developed software run properly after performing several case studies. The power spectra of the data were investigated in order to detect the inception and extent of cavitation. Energy content analysis was also used to support the revealed results by comparing the mRMS ratios of the frequency values of two different ranges. As a conclusion, the spectral analysis methods have been found to be useful tools for this purpose and energy content analysis has been shown to be a good supporting comparison method.
Benzer Tezler
- Biyomagnetik olaylar
Başlık çevirisi yok
M.TOGAN ÇANDIR
Yüksek Lisans
Türkçe
1996
Elektrik ve Elektronik Mühendisliğiİstanbul Teknik ÜniversitesiPROF.DR. İNCİ AKKAY
- X-ışını floresans analiz tekniğinde 99Tc ve 51Cr'in uyarıcı kaynak olarak kullanımı
Başlık çevirisi yok
ASİYE BAŞSARI
Doktora
Türkçe
1997
Nükleer Mühendislikİstanbul Teknik ÜniversitesiNükleer Mühendislik Ana Bilim Dalı
PROF. DR. ŞARMAN GENÇAY
- Marmara Denizi sismik yansıma verilerinin değerlendirilmesi (profil M97-014)
Başlık çevirisi yok
SUNA ÇETİN
Yüksek Lisans
Türkçe
1998
Jeofizik Mühendisliğiİstanbul Teknik ÜniversitesiJeofizik Mühendisliği Ana Bilim Dalı
YRD. DOÇ. DR. AYSUN GÜNEY
- İki boyutlu kafes parametrelerinin sınırlı veri alanlarından hesaplanması
The Calculation of the 2-D lattice parameters from short data records
NURŞEN YILDIZ
Yüksek Lisans
Türkçe
1994
Elektrik ve Elektronik Mühendisliğiİstanbul Teknik ÜniversitesiPROF.DR. AHMET HAMDİ KAYRAN
- Rastgele alanların ar modellemesi için dik kafes süzgeci ve spektrum kestirimine uygulanması
Two-dimensional orthogonal lattice structures for autoregressive modeling of random fields and its use in spectrum estimation
SEDAT TÜRE
Yüksek Lisans
Türkçe
1993
Elektrik ve Elektronik Mühendisliğiİstanbul Teknik ÜniversitesiDOÇ.DR. AHMET H. KAYRAN